行業資訊

水穩攪拌站如何進行良好保養及小心使用？

來源：http://m.81tyre.com/ 日期：2023-02-17

水穩攪拌站是有使用壽命的，如果想讓濟南水穩攪拌站永遠都順利運作，這就需要我們良好的保養以及小心謹慎的使用來延長它的壽命。下面小編為您講解一番：

The water stabilized mixing plant has a service life. If we want to make Jinan water stabilized mixing plant run smoothly forever, we need good maintenance and careful use to extend its service life. The following editor will explain to you:

水穩料攪拌站停機時，整條生產線內嚴禁帶料，在特殊情況下（如機器故障）非人為停車時，要把線內的料干凈，然后再行起動，機器嚴禁滿載和超載起動。

When the water stabilized material mixing plant is shut down, it is strictly forbidden to carry materials in the whole production line. In special circumstances (such as machine failure), when it is not stopped manually, it is necessary to clean the materials in the line before starting. The machine is strictly prohibited to start with full load and overload.

料倉振動器嚴禁空振或長時間振動（當料倉無料或料少時）操作人員要盡職盡責，出現問題立即停車，機器嚴禁帶病工作，操作人員嚴禁擅離工作崗位。為保證骨料倉能連續下料，保證計量精度，除砂、石其余材料（土、石灰、粉煤等）必需用皮帶上料機上料，不允許用裝載機，汽車或挖掘機等直接上料。嚴格保證各種原材料的顆粒徑及含水量。

The silo vibrator shall not vibrate in the air or for a long time (when there is no material or little material in the silo). The operator shall do his duty, stop the machine immediately in case of any problem, and the machine shall not work with disease, and the operator shall not leave the post without permission. In order to ensure the continuous blanking of aggregate silo and the measurement accuracy, other materials except sand and stone (soil, lime, pulverized coal, etc.) must be fed by belt loader, and direct loading by loader, truck or excavator is not allowed. Strictly ensure the particle size and water content of various raw materials.

水穩攪拌站在安全中安裝必須平穩牢固，必須搭設防雨、防砸或保溫的工作棚。操作地點經常保持整潔，棚外應挖設排除清洗機械廢水的沉淀池。電源接線必須正確，必須要有可靠的保護接零(或保護接地)和漏電保護開關，布線和各部絕緣必須符合規定要求。

The water-stabilized mixing plant must be installed stably and firmly in safety, and a rain-proof, anti-smashing or thermal insulation work shed must be set up. The operation site should always be kept clean and tidy. A sedimentation tank should be dug outside the shed to drain the waste water from cleaning machinery. The power supply wiring must be correct, and there must be reliable protective neutral connection (or protective grounding) and leakage protection switch. The wiring and insulation of each part must meet the specified requirements.
濟南水穩攪拌站

(由電工操作)操作人員必須是經過培訓，并經考試合格，取得操作證者，嚴禁非操作人員操作。操作工必須按清潔、緊固、潤滑、調整、防腐的十字作業法，每次對水穩攪拌站進行認真的維護與保養。

(Operated by electricians) The operators must be trained, pass the examination and obtain the operation certificate. Non-operators are prohibited to operate. The operator must carefully maintain the water stabilized mixing plant every time according to the cross operation method of cleaning, fastening, lubricating, adjusting and anti-corrosion.

每次工作開始時，應認真檢視各部件有無異?，F(xiàn)象。開機前應各部件有無破損，是否良好，機身是否平衡，周圍有無障礙，確認沒有問題時，方能合閘試機。

At the beginning of each work, carefully inspect all parts for abnormalities. Before starting the machine, check whether all parts are damaged, whether they are in good condition, whether the machine body is balanced, and whether there are obstacles around. Only when it is confirmed that there are no problems can the machine be switched on and tested.

以2~3分鐘試運轉，滾筒轉動平衡，不跳動，不跑偏，運轉正常，無異常聲響后，再正式生產操作。機械開動后，司機必須思想集中，堅守崗位，不得擅離職守。

After the test run for 2~3 minutes, the drum rotates evenly, without jumping, deviation, normal operation, and no abnormal noise, the formal production operation can be started. After the machine is started, the driver must concentrate on his/her position and not leave without permission.

并須隨時注意機械的運轉情況，若發現不正?，F(xiàn)象或聽到不正常的聲響，必須將攪拌機內的存料放出，停機進行檢修。水穩攪拌站在運轉中，嚴禁修理和保養，并不準用工具伸到筒內扒料。更多相關內容就來我們網站http://m.81tyre.com咨詢吧！

Pay attention to the operation of the machinery at any time. If abnormal phenomena are found or abnormal noises are heard, the stored materials in the mixer must be discharged and the machine must be shut down for maintenance. When the water stabilized mixing plant is in operation, it is strictly forbidden to repair and maintain it, and it is not allowed to use tools to stretch into the drum to pick up materials. Come to our website for more relevant content http://m.81tyre.com Ask!

上一條：挖掘機租賃可以給你帶來的好處有哪些？

下一條：瀝青砼到底是什么材料？