對于公路項目施工而言，采用水泥穩定碎石技術，其主要原理為根據一定比例混合碎石、凝膠與灰漿等材料，采用嵌擠與壓實相結合的原理進行壓實，對出現的孔隙采用足量的灰漿與細集料填充。那么公路施工中應用水泥穩定碎石的相關準備工作怎么樣呢？
For the construction of highway projects, the cement stabilized macadam technology is adopted. Its main principle is to mix macadam, gel and mortar in a certain proportion, and use the principle of combination of embedment and compaction to compact. The pores that appear are filled with sufficient mortar and fine aggregate. How about the preparation work related to the application of cement stabilized macadam in highway construction?
在公路施工項目應用水泥穩定碎石前，要認真檢查項目基層施工質量是否達標，一旦施工質量不符合標準，直接影響到項目整體施工質量。項目基層施工質量檢測主要包含：檢查其寬度、平整度、坡度、壓實狀況及外觀等，必須要符合要求規定，以此提高基層施工質量。
Before applying cement stabilized macadam in highway construction projects, it is necessary to carefully check whether the construction quality of the project base meets the standard. Once the construction quality does not meet the standard, it will directly affect the overall construction quality of the project. The quality inspection of project base construction mainly includes: checking its width, flatness, slope, compaction condition and appearance, which must meet the requirements, so as to improve the quality of base construction.
在公路工程施工中，施工前期準備與放樣同等重要，采用全站儀設備測定路面中線，分別在直線段/20m與曲線段/10m處設置木樁，在距路邊緣外側半米位置設置指示樁，便于項目進行水平策略，同時選用紅漆進行標注，并在紅漆涂刷位置增加鋼絲繩，根據施工現場實際環境與路面設計方案，準確設計路面邊線。
In the construction of highway engineering, the preparation in the early stage of construction is as important as setting out. The total station equipment is used to measure the center line of the pavement. Wooden piles are set at the straight section /20m and curve section /10m respectively, and indicator piles are set at the position half a meter away from the outside of the road edge to facilitate the horizontal strategy of the project. At the same time, red paint is selected for marking, and steel wire rope is added at the position where red paint is painted. According to the actual environment of the construction site and the pavement design scheme, Accurately design the pavement sideline.
水泥穩定碎石被應用于實際施工中前，要確保其配置的合理性，通常采用穩定土廠拌合設備與方法相結合，嚴格依照實驗配比選用配料配置水泥穩定碎石。由于這一過程中水分會損失，因此在方案設計中，含水量要高出佳量0.5~1%，但水泥劑量不能改變。
Before the cement stabilized macadam is applied in the actual construction, it is necessary to ensure the rationality of its configuration. Usually, the mixing equipment and method of the stabilized soil plant are combined, and the ingredients are selected and configured in strict accordance with the experimental proportion. Due to the loss of water in this process, in the scheme design, the water content should be 0.5~1% higher than the optimal amount, but the cement dosage cannot be changed.

采用拌合機調配這些混合原材料，保證配置標準，達到無花面、花團及灰條。待這些混合物材料拌合完成后，要及時去除其中含有的粗細顆粒物，如果情況不理想，則要進行二次拌合，直到達到標準后方可及時將其運輸至施工現場，并進行攤鋪與壓實施工工藝。
The mixing machine is used to mix these mixed raw materials, so as to ensure the configuration standard and achieve no flower surface, flower ball and ash strip. After the mixing of these mixture materials is completed, the coarse and fine particles contained in them should be removed in time. If the situation is not ideal, the second mixing should be carried out, and they can be transported to the construction site in time until they meet the standard, and the paving and compaction construction process should be carried out.
濟南水泥穩定碎石廠家提醒大家，必須要注意的是，在拌合物運輸中要均勻裝載，根據實際情況合理選擇運輸車輛。一般，水泥穩定碎石從拌合-攤鋪-壓實，整個過程不超過3h，特別是要低于拌合物終凝固實踐，因此自卸運輸車為合適，此外在運輸中要在混合物上覆蓋塑料薄膜，以防水分蒸發。
Jinan cement stabilized macadam manufacturer reminds everyone that it must be noted that the mixture should be evenly loaded during transportation, and the transportation vehicles should be reasonably selected according to the actual situation. Generally, the whole process of mixing paving compaction of cement stabilized macadam shall not exceed 3h, especially lower than the final setting practice of the mixture. Therefore, dump trucks are suitable. In addition, plastic films shall be covered on the mixture during transportation to prevent evaporation.
以上就是問題解答的相關內容了，希望能夠幫助到大家，如對這一問題還存在任何疑問，都歡迎關注我們網站http://m.81tyre.com并咨詢我們的工作人員，將竭誠為您服務。
The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website http://m.81tyre.com And consult our staff, will serve you wholeheartedly.